«上一篇/Previous Article|本期目录/Table of Contents|下一篇/Next Article»

《合成橡胶工业》[ISSN:1000-1255/CN:62-1036/TQ]

期数:

2022年4期

页码:

309-313

栏目:

出版日期:

2022-07-15

文章信息/Info

Title:

Structure and properties of high-content rubberized asphalt

文章编号:

1000-1255（2022）04-0309-05

作者:

于晓晓; 杨 渭; 路永春; 李晓暾; 王仕峰

1.上海交通大学 化学化工学院，上海 200240；2.甘肃公航旅建设集团有限公司，兰州 730000

Author(s):

YU Xiao-xiao;  YANG Wei;  LU Yong-chun;  LI Xiao-tun;  WANG Shi-feng

1.School of Chemistry and Chemical Engineering, Shanghai Jiao Tong University, Shanghai 200240, China； 2.Gansu Provincial Highway Aviation Tourism Investment Group Co Ltd, Lanzhou 730000, China

关键词:

橡胶沥青; 高掺量; 胶粉; 降解再生; 加工性能

Keywords:

rubberized asphalt;  high-content;  ground tire rubber;  degradation regeneration;  processability

分类号:

U 415.6

DOI:

DOI:10.19908/j.cnki.ISSN1000-1255.2022.04.0309

文献标识码:

B

摘要:

轮胎胶粉的多重交联网络限制了其在橡胶沥青中的胶粉掺量。用经螺杆反应挤出方法可控再生的再生胶可制备高掺量（质量分数不小于30%）橡胶沥青。通过溶胶含量、门尼黏度和基本性能测试及加工实况观察，并结合红外光谱和光学显微镜微观分析，探讨了胶粉的再生程度及用量对高掺量橡胶沥青结构与性能的影响。结果表明，再生过程中胶粉的化学键发生断裂，部分交联网络被破坏。与传统橡胶沥青相比，高掺量橡胶沥青的分散更均匀，加工流动性和高温储存稳定性均得以改善。提高胶粉的降解再生程度可明显提高其在沥青中的掺量，进一步提高改性沥青的低温柔性和高温抗变形能力，但易出现加工黏度的临界陡增现象。

Abstract:

The content of ground tire rubber was limited by its multiple cross-linking networks. High-content ground tire rubber modified asphalt （mass fraction of ground tire rubber more than 30%） binder could be produced by addition of degraded tire rubbers （DR）, which was controllably prepared by reactive screw extrusion using ground tire rubber. The effects of degradation degree and content of DR on structure and properties of DR modified asphalt were analyzed by Soxhlet extraction, Mooney visco-sity, basic physical properties, infrared spectroscopy, and optical microscopic tests. The results showed that chemical bonds broke, and cross-linking network of ground tire rubber collapsed during degradation process. Compared with conventional ground tire rubber modified asphalt binder, DR modified asphalt binder had finer dispersion, lower viscosity and better stability at high temperature. The addition of DR with high degree of degradation increased by a large margin the content of ground tire rubber, leading to further improved deformation ability at low temperature and deformation resistance at high temperature. The steep increased of viscosity at certain rubber content should be noticed.

参考文献/References

[1] Mashaan N S， Ali A H， Karim M R， et al. A review on using crumb rubber in reinforcement of asphalt pavement[J]. The Scientific World Journal， 2014， 2014： 214612.[2] Yang Xu， You Zhanping， Perram D， et al. Emission analysis of recycled tire rubber modified asphalt in hot and warm mix conditions[J]. Journal of Hazardous Materials， 2019， 365： 942-951.[3] Yao Hongru， Zhou Shuai， Wang Shifeng. Structural evolution of recycled tire rubber in asphalt[J]. Journal of Applied Polymer Science， 2016， 133 （6）： 1-7.[4] Ghavibazoo A， Abdelrahman M， Ragab M. Mechanism of crumb rubber modifier dissolution into asphalt matrix and its effect on final physical properties of crumb rubber-modified binder[J]. Transportation Research Record， 2013， 2370 （1）： 92-101.[5] 李岩， 张勇， 张隐西. 废橡胶的国内外利用研究现状[J]. 合成橡胶工业， 2003， 26（1）： 59-61.[6] Venudharan V， Biligiri K P. Effect of crumb rubber gradation on asphalt binder modification： Rheological evaluation， optimization and selection[J]. Materials and Structures， 2017， 50（2）： 129-142.[7] Xie Yanling， Hassan A A， Song Pan， et al. High scission of butadiene rubber vulcanizate under thermo-oxidation[J]. Polymer Degradation and Stability， 2019， 167： 292-301.[8] Chen Siyu， Gong Fangyuan， Ge Dongdong， et al. Use of reacted and activated rubber in ultra-thin hot mixture asphalt overlay for wet-freeze climates[J]. Journal of Cleaner Production， 2019， 232： 369-378.[9] 张广泰， 方烁， 叶奋. 双螺杆挤出胶粉改性沥青流变性能研究[J]. 中国公路学报， 2019， 32（5）： 57-63.[10] 叶奋， 杨思远， 吴晓羽， 等. 深度降解橡胶改性沥青的流变性能[J]. 建筑材料学报， 2016， 19（5）： 945-949.[11] Song Pan， Zhao Xinyu， Cheng Xiangyun， et al. Recycling the nanostructured carbon from waste tires[J]. Composites Communications， 2018， 7： 12-15.[12] Wu Xiaoyu， Wang Shifeng， Dong Ruikun. Lightly pyrolyzed tire rubber used as potential asphalt alternative[J]. Construction and Building Materials， 2016， 112： 623-628.[13] Dong Ruikun， Li Jinliang， Wang Shifeng. Laboratory evaluation of pre-devulcanized crumb rubber-modified asphalt as a binder in hot-mix asphalt[J]. Journal of Materials in Civil Engineering， 2011， 23（8）： 1138-1144.[14] Yu G X， Li Z M， Zhou X L， et al. Crumb rubber-modified asphalt： Microwave treatment effects[J]. Petroleum Science & Technology， 2011， 29（4）： 411-417.

备注/Memo

备注/Memo:

国家重点研发计划项目（2021 YFE 0105200）

常用功能

更新日期/Last Update: 2022-07-15